EverExceed Nickel Cadmium Rechargeable Batteries for Aviation Vehicle / Military Vehicle

EverExceed Nickel Cadmium battery solutions for jetliners provide a combination of long life duration, high
reliability, ultra low maintenance and low lige cycle cost based on mature Ni-Cd electro-chemistry.

Q: What is an AGM battery?

A: An AGM battery is a lead-acid battery that is sealed using special pressure valves and completely maintenance-free. It has all of its electrolyte absorbed in separators consisting of a sponge-like mass of matted glass fibers, and uses a recombination reaction to prevent the escape of hydrogen and oxygen gases normally lost in a flooded lead-acid battery (particularly in deep cycle applications).

Q: What is a GEL battery?

A: A gel battery is a lead-acid battery that is sealed using special pressure valves and completely maintenance-free. It uses thixotropic gelled electrolyte and uses a recombination reaction to prevent the escape of hydrogen and oxygen gases normally lost in a flooded lead-acid battery (particularly in deep cycle applications).

Q: What is a NiCad Battery?

A: The nickel cadmium battery is a type of rechargeable battery using nickel oxide hydroxide and metallic cadmium as electrodes. EverExceed manufactures pocket plate and sintered plate nicad batteries.

Q: What is battery rating?

A: The most common battery rating is the Ampere-hour Rating. The capacity of a battery, in Ahs, is a dynamic number that is dependent on the discharge current.For example: 10 amperes for 20 hours (10 x 20) = 200 Ah @ the 20-hour rate.

Q: How can you tell if a VRLA battery has been damaged by under- or overcharging?

A: The only way is with a load test. Use the same procedure you would use with a wet cell battery:

a. Recharge if the open circuit voltage is below 75%.

b. If adjustable, set the load at 1⁄2 the CCA rating or three times the 20 hour rate.

c. Apply the load for 15 seconds. The voltage should stabilize above 9.6 volts while on load.

d. If below 9.6 volts, recharge and repeat test.

e. If below 9.6 volts a second time, replace the battery.

Q: How long does it take to recharge a fully discharged VRLA battery?

A: A specific time is difficult to determine because recharging depends on the following factors: depth of discharge; temperature; size and efficiency of the charger; age and condition of the battery.

Q: How do I select the right battery for my applications?
A: Proper battery selection may require the assistance of a knowledgeable battery sales or service technician. Please consult EverExceed for more details. 

Tag: lead acid battery, AGM battery, GEL battery, valve regulated lead acid battery, rechargeable lead acid battery, deep cycle deep acid battery, starting lead acid battery, automotive battery, spiral lead acid battery, forklift battery, flooded lead battery, NiCad battery, lithium-ion battery.

Keyword: lead acid battery

More products

Battery:  

Lead Acid Battery, Car Battery , Forklift Battery , Golf Battery, Nickel Cadmium/ Nickel Iron Battery, Lithium Battery

Solar panel products:

Solar Panel, Solar System Solution , Grid-off/on Inverter , Inverter & charger , Solar controller

Power supply products:

UPS power products, Charger, Telecom Rectifier , AVR , LED light